jerold
New member
helo everybody,please help me on my problem,my steering is very noisy.when turn it,either left or right,there is a noise.please help me tnx.
steering very noisy
- Thread starter jerold
- Start date
ArtMech
Platinum Member
- Joined
- Oct 5, 2010
- Messages
- 968
- Location
- Lithuania, EU
- Tractor
- Present: 2003 Kubota M9000 DTF; 2001 Kubota GB15. Sold: 1985 Kubota L2202
Welcome to TBN!
I'll second to the issue jerold has so to avoid double oppening the thread on the same failure. My steering (well it's not JD but M9000) is also noisy. Not much, but a little bit. Noise comes from the controller right under the steering wheel at both steering wheel travel end positions.
The troubleshooting says about the noise:
- Air sucked in pump due to lack of oil
- Air sucked in pump from suction circuit
- Pipe deformed
Had some clear visible oil leakage on the RH side of steering cylinder. Replaced the seal. No leakage anymore. But the noise still didn't disappear. Not so long ago have noticed the LH side of cylinder is wet of oil. Hope after replacement of that LH seal an issue of noise will be solved. Or not.
Any suggestions would be very very welcomed. Thanks in advance.
I'll second to the issue jerold has so to avoid double oppening the thread on the same failure. My steering (well it's not JD but M9000) is also noisy. Not much, but a little bit. Noise comes from the controller right under the steering wheel at both steering wheel travel end positions.
The troubleshooting says about the noise:
- Air sucked in pump due to lack of oil
- Air sucked in pump from suction circuit
- Pipe deformed
Had some clear visible oil leakage on the RH side of steering cylinder. Replaced the seal. No leakage anymore. But the noise still didn't disappear. Not so long ago have noticed the LH side of cylinder is wet of oil. Hope after replacement of that LH seal an issue of noise will be solved. Or not.
Any suggestions would be very very welcomed. Thanks in advance.
Last edited:
ArtMech
Platinum Member
- Joined
- Oct 5, 2010
- Messages
- 968
- Location
- Lithuania, EU
- Tractor
- Present: 2003 Kubota M9000 DTF; 2001 Kubota GB15. Sold: 1985 Kubota L2202
Just to end up a subject concerning my issue.
Yes, right after I have replaced a seal on another (LH) side of steering cylinder, the noise from the steering system disappeared completely.
Yes, right after I have replaced a seal on another (LH) side of steering cylinder, the noise from the steering system disappeared completely.