pdsrms
Member
If I am careful to keep it clean, can I recycle my hydraulic fluid during the change of filters? ~10 gallons. Kubota L39.
200 hrs service, Waste hydraulic fluid ??
- Thread starter pdsrms
- Start date
Shimon
Platinum Member
pdsrms said:
You can do whatever you want...but it's recommended that you change the fluid, not reuse it. You get what you pay for.
DieselPower
Elite Member
- Joined
- Sep 30, 2006
- Messages
- 2,756
- Location
- Fairfield, PA
- Tractor
- JD 3020, JD 4230, JD 7410, JD 2440, MF 750, NH LS170
I would only extend drain intervals if you are doing a UOA (used oil analysis) on it. If your not I would highly recomend NOT reusing it. The particles that kill engines, pumps, cylinders .... are way to small for you to see with the naked eye.
wushaw
Elite Member
Does your the manual only says to change the filters at 200hrs...if so then just do that.
You can jack up the ft. of the tractor so most of the fluid will rest in the rear and you won't loose it all and be quick on the R/H filter change.
You can jack up the ft. of the tractor so most of the fluid will rest in the rear and you won't loose it all and be quick on the R/H filter change.
KennyV
Elite Member
- Joined
- Sep 1, 2004
- Messages
- 2,601
- Tractor
- Kubota L4200 GSTCA
This works well, and is cleaner than engine oil or cooking oil… Recoup around $3.00 a gallon as fuel. KennyV.SPYDERLK said:
Soundguy
Old Timer
- Joined
- Mar 11, 2002
- Messages
- 51,575
- Location
- Central florida
- Tractor
- RK 55HC,ym1700, NH7610S, Ford 8N, 2N, NAA, 660, 850 x2, 541, 950, 941D, 951, 2000, 3000, 4000, 4600, 5000, 740, IH 'C' 'H', CUB, John Deere 'B', allis 'G', case VAC
Somehow.. putting wast oil into my engine just doesn't seem like a great thing for the fuel system.
If direct recycling of used fluid was such a great idea.. people would be drinking urine.. it's sterile and mostly water after all ... right?
Only clean fuel and clean oil goes into my tractor sumps... why gamble with anything else unless you have the equipment to re-refine the oil..
Much of the concept of changing oil is to get rid of contaminants in the oil ( the rest being replacement of the base oil and add apckages after them oxidizing and being depleted or broke down.. etc.. )
Soundguy
If direct recycling of used fluid was such a great idea.. people would be drinking urine.. it's sterile and mostly water after all ... right?
Only clean fuel and clean oil goes into my tractor sumps... why gamble with anything else unless you have the equipment to re-refine the oil..
Much of the concept of changing oil is to get rid of contaminants in the oil ( the rest being replacement of the base oil and add apckages after them oxidizing and being depleted or broke down.. etc.. )
Soundguy
DieselPower
Elite Member
- Joined
- Sep 30, 2006
- Messages
- 2,756
- Location
- Fairfield, PA
- Tractor
- JD 3020, JD 4230, JD 7410, JD 2440, MF 750, NH LS170
Very good point Soundguy. I have alway's recomended AGAINST adding any type of engine or hydraulic oil be it new or used into a fuel system. Even new unused oil is anywhere from 10-25%+ additive package, many of which are non flamable additives. On top of that if you use used oil your also dumping all the contamination into your fuel system. If you want to add something to your fuel use a fuel additive that is formulated for it.
If you want to burn your waste oil do what I did, buy a wast oil burner to heat your shop.
If you want to burn your waste oil do what I did, buy a wast oil burner to heat your shop.
rdsaustintx
Veteran Member
Dump the stuff on your burn pile, if disposing of brush and trees. Makes green wood burn a bit better, no residue, saves a trip to recycling center.