mahindra 4500

MY Mahindra 4500 2wd primer not priming. Primer head will not pull up. Plus pressing the fuel paddle/rpm arm does nothing. What wrong???

We have replaced the injectors, starter, ignition, bled all the lines, then we off the fuel injection pump and it dont seem like its pushing out that mush fuel. What had happened was while tilling our arena the tractor starting to blow really black smoke so he shut PTO down and slowed tractor...

What kind of transmission fluid do you use in a 2003 Mahindra 4500 tractor

While operating in the field the 3 point lift worked fine. But when I got to the barn, the lift would not go down. The loader workds fine to all positions. I verified draft control lever was not up, verified the draft control sensor pin was not stuck inside the housing. I have not tried moving...

Hello everyone, I have a mahindra 4500 series tractor. I recently replaced the clutch and was able to move it to put back on the front loader but was now having issues with it starting over already checked fuel lines, fuses, wires and no luck, it cranks but no start.. HELP!

I have my Mahindra 4500 2wd front tires jacked up off the ground. I have just repaired my tractor from overheating power steering fluid, by replacing the seals in the front wheel cylinder. I was able to turn both wheels over the past three weeks while working on the over heating issue. Now the...

I own a 85-60 Mahindra and an old 3000 ford diesel 2wd. I use both tractors for bush hoging and general work, I have some property that I use the 3000 on and have to trailer it there. I am having shoulder problems and am having trouble steering the old 3000, no power steering. I saw a Mahindra...

Probably a dumb question, but where is the main engine oil dipstick located on an older model Mahindra 4500 2-wheel drive tractor? I've looked everywhere for that sucker. thanks in advance.

I have a 4500 2 wheel drive I had a leak under my steering wheel this past summer, it turned out to be a leak in the steering box called the (H) box located under the tractor steering wheel, a seal in the top of the steering box. leaking steering fluid out the top of the tractor under the...

My Mahindra can turn a little to the right and a little to the left, I cannot make a sharp turns, when I do my steering wheel turn round and round and the front wheel are not turning much, all this is when the tractor is running and moving. To turn around I would need to male a large wide...

I have a mahindra 4500 4wd, has 3 cylinder engine. It has always crank as soon as it turns with no problem until now. I was using it to spray fence line when all at once it puff black smoke. Now when you crank the engine it will turn and turn like it is trying to pick up fuel and puff black...

Is there a detailed parts catalog ideally with an exploded diagram of most parts like one can find for JD tractors for a Mahindra 4500 2WD, 2001 vintage?? Where should I look? Thanks Gary

My Mahindra 4500 has stopped lifting up the bush hog cutter. It takes all my muscle to pull back the level that lifts the bush hog. It worked ok in the past year. I checked the H-fluid behind the seat, it is full up to the stick level. The bush hog lift level appear to be locked down or...

I have a Mahindra 4500, 2-wheel drive. I need someone to tell me what are the handle knob on:mad:the right side of the sit are and what each one do. OK first I believe the long bar handle with the cap on the end that push in is the breaks. This handle I believe needs to be down when operating...

I am looking to change the radiator fluid on my 4500 and operators manual says "two drain plugs must be opened. One is on L.H. side of crankcase and one on radiator bottom tank. Anyone know where the plug on LH side of crankcase is located?

Hello, just wanted to ask if anyone out there has changed the transmission/Gear box oil on a Mahindra4500-5500 or 6000 tractor - crawling under the tractor - Not sure which bolt is the drain plug - this model of tractor calls for the 80-90 gear oil. Thanks for your help.

Hello, I have a 2003 Mahindra 4500 4 x 4, looking at changing the transmission/gear oil. My user manual does not show or discuss the process to change the transmission fluid. Just wanted to ask if someone out there is familiar with this tractor and would offer some advise on how to complete...

Where is the dip stick on the 4500? Was trying to check oil on FIL tractor today and can't find it anywhere.

I have a Mahindra 4500 4wd serial # US 1258 J2. I have a power steering leak at the steering cylinder outer end. The steering cylinder has the following stamped on it: OGNIBENE FOR CRR DE 50/22X200 23 3 970200100 1 18542 I am trying to find a reseal kit for the out end (where endcap is...

Okay, so ive been dealing with this for a month now. I cannot figure out whats going on. So let me tell you first what happened, and then what ive done. I was mowing my pasture on 3/4 of a tank, it ran fine for 2 hours then started acting like it was wanting to bog down (like it would when...

Father in law had a Mahindra 4500 til he passed several years ago. Doesn't get a lot of use. Mostly putting out a couple round bales each week. Recently was on it and it just started running very ragged then seemed to straighten up a bit then died. I don't know where the manual is and thought...

MY power steering box get low on fluid after about 20 minutes of cutting. I can refill the power fluid box and everything is good, front wheel turn perfectly, than 20 minutes later it become hard to turn and I have to turn the steering wheel around and around to just turn the tires a little. The...

Can someone please list the specifications of the recommended lubricants for my tractor. I do not have a manual and would like to know the recommended fluids to include capacity of engine oil, hydraulic fluid, power steering fluid, engine coolant, and any other that I might have missed.

My tractor is leaking power steering fluid from the bottom of the steering wheel. The leak must originate down at the HSU and is pushing fluid up. Has anyone had this problem?? Is there an o ring or seal in top of the HSU that can be replaced?? Difficulty? Any help will be appreciated.

Have had a small leak in the control box at the base of the steering wheel shaft for some time. Now it is a gusher. Fluid was coming out near the top of the steering column. Have bought the kit ($115 for 5 small O rings and seals) but am not sure what tools I will need to tackle the...

Looking for "knowledge" on how to repair "spewing" HSU on my Mahindra 4500 4wd...it has the gray/black HSU which I am told is an Eaton brand HSU. Any help appreciated on this latest repair.

I have a 2002 Mahindra 4500, 2wd, no FEL, with optional installed jerry can & rear wheel weights. Book says tractor weighs 4752 (assuming standard features?). Any idea what the tractor weighs including the optional weights?

Recently purchased a 2002 Mahindra 4500 2wd, no FEL. It has the optional front and rear weights from the factory. Tractordata shows weight at 4752. Need to know approx weight. TIA...

Does anyone know the value of 2002 mahindra 4500

On the dash panel on the left side, there is one panel that shows temp with a range of 221>>>240 with a F in the middle of the gauge range, as I am running my tractor with the bush hall, the hand on this gauge goes over to the middle on the F after running/cutting 30 min's or more, is this...

I also make the mistake and removed the wrong filter, the long filter, which I believe is the Hydraulic oil filter. Can I just refill the new one and tighten it back on, or did I loose some hydraulic oil and need to add more hydraulic oil? Where is the hydraulic oil stick to check the hydraulic...

My 4500 has sprung a leak, real bad one, ps fluid coming out at dash around steering wheel. Anyone had this to happen? My take on it after looking at the diagram is at the bottom section where the lines go in, the pressure seal must be bad. It is not obvious to me how it comes apart and if can...

Can anyone please tell me best way to change out clutch on mahindra 4500. I am a new member. Thank you.

I was pushing snow today when suddenly the steering wheel became comletely worthless. It spins freely as if it sheared a pin or the like. It has hydraulic oil in the reservoir, the wheels when lifted by the loader will turn very minimally about 1/2-3/4 inch on the steering cylinder. I can not...

This information may help someone else out there. My 4500 would not shift well into reverse. It started with about 700 hours on the machine. At first it would grind a little, after a few months, it would not shift into reverse at all. Not good for a machine we use almost everyday. Removed the...

I have a 4500 with 450 hours on it. When using the PTO, it occasionally disengages. To re-engage, you have to clutch in ALL the way instead of just being able to clutch in a small amount. Anyone have any suggestions?

I'm trying to find the fill hole for the transmission, I found the drain plug, also how do you refill the rear differential? Again, I found the drain plug.

HELLO ALL... MY TACH QUIT .. I HIT THE GLASS AND IT STARTS AGAIN... DO YOU KNOW OF A RECALL OR IF THERE IS A COLD SOLDER JOINT PROB.. I'LL CALL DEALER TOMORROW.. BO..

I need help!! My Mahindra 4500 2wd will not go into 1st, 2nd, or reverse. Third and fourth work as they should as does the hi-lo selector. Any insight on what could be the problem?

Hello everyone I have a Mahindra 4500 that has given me great service. I now have a problem where it will not turn over. It acted up some last weekend but I moved the forward reverse lever back and forth until it started. I can only assume there is a safety switch somewhere. Anyone know where...

I did some searching on this topic and the more I researched the more confused I became. As you can tell this is my first tractor and my first diesel anything so I am a real newbe. So here is the question, is it okay to run ultra low sulphur highway diesel in my 2006 4500 Mahindra ? I have 5...

I thought this would be pretty easy to find on the internet but have really struck out so far. Anybody got a real good guess on total weight of tractor with loader ? 5000 #? Thanks

230 hours hour meter stopped working 5 or 6 tanks of fuel later herd buzzing sound by relays whe key was turned on, and battery was dead. pulled battery and charged, while installing battery the cables sparked alot but stopped. tractor started great but all guages were dead. turn signals and...

Mahindra Owners, I bought my Mahindra 4500 4WD on 11 Nov 2003. That was before it was renamed the 4503. Since then I have had to replace the radiator-side oil cooler hose at the oil cooler four times. I'm getting ready to do it again for the fifth time. The first time it had developed a 1/2 long...

Hi I was wondering if anyone has had a problem with the transmission and/or hydraulic resevoir under the seat over heating on the Mahindra 4500? I've noticed that mine has been after about a half hour of use since it was new, and it now only has about 100 hours on it... so hot you could fry an...

i just bought my first tractor, a mahindra 4500 2wd with loader, box blade, 6' shredder. and a trailer for $17895.00 i just have 14 hours on it. this tractor really really has to warm up or it will sputter when you throttle up. once the temp gauge gets up to as far as it goes " about 1/4 of an...

I have a 2002 Mahindra 4500 with 250 hours on the tractor. I am experiencing severe power loss. I originally thought that I had purchased some contaminated fuel, I drained a couple of gallons out of my tank through the bottom drain valve and the diesel looked ok, no water. I have changed my...

After damaging the thin sheet metal tool box that came with the tractor, I decided to build a tool box that is a wider and taller than the original one. I had some extra 1/8" Diamond Plate. It's a good thing it's mounted to the tractor, because I would not want to carry this thing around...

I'm sure this has been asked before, but I'm sort of a newbie. What are you folks' impressions of the Mahindra 4500. Never thought about the Mahindras much until now...area dealer is offering some great incentives etc. The 4500 should do what I want with a 6-8' shredder, box blade, and maybe...

I am looking for some advise on removing and installing the primary and secondary fuel filters. I read the manual. It looks cut and dry. When I went out to locate them on the tractor, completely different story. The clearance between the primary filter and the starter housing is frustratingly...

I am concidering the purchase of a 4500 4x4 I run a small fire wood bussiness in the summer and am looking to use the loader to pick up the sticks so I can cut them I am also concidering putting a backhoe attachement on it for use in the yard Is the 4500 to big for what I want to do? how is...

What\'s a fair price for a Mahindra 4500 and 3510? Does anyone know a fair price for a Mahindra 3510 and a 4500 with and with out a FEL?

I am looking to buy my first tractor, a Mahindra 4500. Can anyone tell me about the pros and cons of the constant running PTO (CRPTO). Also, I would like to hear from anyone who owns a 4500 and if they have had any problems with it. Thanks

Here is a picture of my tractor, after putting on a new fiberglass canopy. What do you think????

Has anyone out there made or purchased a Canopy for their Mahindra Tractor. I recently purchased my Mahindra, the only thing missing is some protection from that Arizona Sunshine . Any input would be appreciated. Scott

Hello, I am thinking about purchasing the Mahindra 4500 4x4, just wondering what others have expierenced. I have heard mostly positive feedback from the Mahindra Brand. I live in AZ and will be using the tractor to maintain a private road to my property. Any thoughts or recommendations would...

mahindra-ML-238415-ML- Moved to Mahindra Forum.

I posted this message in the general buying pricing forum also, I have been browsing this site for some time and just wanted to say thanks to all the posters who led me to Mahindra. I am now the proud owner of a 4500 4wd w/fel and 6'' foot brushhog for $19,595 delivered from 70 miles away...