TC55DA cuts out while driving

devildog26 · Jun 3, 2006

I have a brand new TC55DA with 10 hours on it.. I had a sprayer on the back and had the RPM up to about 2000 and as I drove and sprayed the tractor would just start to loose power and die. If I slowed down and put it in neutral I could recover it before it died but it would not rev up for a little bit and just chugged. I tried that with the PTO on and off and it still did it either way. But if I got off the tractor and turned the RPM up real high for the PTO and let it run it did not stall only when I was driving.. Does anyone have any ideas?

Thanks,

Bill

devildog26 · Jun 3, 2006

I have a brand new TC55DA with 10 hours on it.. I had a sprayer on the back and had the RPM up to about 2000 and as I drove and sprayed the tractor would just start to loose power and die. If I slowed down and put it in neutral I could recover it before it died but it would not rev up for a little bit and just chugged. I tried that with the PTO on and off and it still did it either way. But if I got off the tractor and turned the RPM up real high for the PTO and let it run it did not stall only when I was driving.. Does anyone have any ideas?

Thanks,

Bill

dqdave1 · Jun 3, 2006

Sounds like a fuel filter is plugged with water or dirt or debris. Remove filter and clean. then see if that cures problem. You may have gotten some bad fuel.

dqdave1 · Jun 3, 2006

Sounds like a fuel filter is plugged with water or dirt or debris. Remove filter and clean. then see if that cures problem. You may have gotten some bad fuel.

PineRidge · Jun 3, 2006

While you're spun around could you be lifting part of your weight off the seat? I had a case while snow blowing where my engine was cutting out and made a determination that that's what was happening in my case. Sometimes I wonder if it would be a good idea to just bypass the seat switch.

PineRidge · Jun 3, 2006

While you're spun around could you be lifting part of your weight off the seat? I had a case while snow blowing where my engine was cutting out and made a determination that that's what was happening in my case. Sometimes I wonder if it would be a good idea to just bypass the seat switch.

devildog26 · Jun 3, 2006

Thanks for all the help.. I will look at the fuel filter and also pay attention and see if it is the way i am sitting on the seat. I will let you know what i find out...

Thanks again.

devildog26 · Jun 3, 2006

Thanks for all the help.. I will look at the fuel filter and also pay attention and see if it is the way i am sitting on the seat. I will let you know what i find out...

Thanks again.

Soundguy · Jun 4, 2006

When my Nh 7610s did that it was fuel starvation..

Check water traps and filters.. check fuel level.. and flow from tap.. might be a plugged tank tap screen ( mine was ).. bleed lines and try her out.

Soundguy

Soundguy · Jun 4, 2006

When my Nh 7610s did that it was fuel starvation..

Check water traps and filters.. check fuel level.. and flow from tap.. might be a plugged tank tap screen ( mine was ).. bleed lines and try her out.

Soundguy