PTO seal leaking

   / PTO seal leaking #1  

3gunr

Veteran Member
Joined
Apr 17, 2018
Messages
1,182
Location
wentzville mo
Tractor
mahindra 2538 mahindra 2810 cub cadet 7260 massey 255
My mahindra 2538 pto seal has a slight leak, I have the new seal and am wondering if i should use some type of gasket sealer on the gasket or not
 
   / PTO seal leaking #2  
I usually put a little oil or grease but mainly use whatever fluid it it restraining on the lip when installing seals.
 
   / PTO seal leaking #3  
I only grease both sides of gasket, and inside of seal.
 
   / PTO seal leaking #4  
Usually they don't leak unless the fluid in the gearbox is too high. It needs to be below the seal lip, or if the outboard bearing has excessive radial play.
 
   / PTO seal leaking
  • Thread Starter
#5  
the hyd fluid sightglass is higher than the pto seal , so i assume the fluid is also so not sure what you mean by fluid being to high ?
 
   / PTO seal leaking
  • Thread Starter
#7  
The sightglass is even with the top of the pto shaft The level fluid line is just above the shaft , So the lower 2/3 of the seal has fluid on it,
 
   / PTO seal leaking #8  
I usually go by how the original gasket was installed. If it had some form of sealant I use some on the replacement. If not install it without.
 

Tractor & Equipment Auctions

2012 CATERPILLAR 140M2 MOTOR GRADER (A52706)
2012 CATERPILLAR...
2016 Chevrolet Impala Limited Sedan (A55853)
2016 Chevrolet...
2007 IC Corporation PB105 School Bus (A54814)
2007 IC...
(INOP) 2018 BOMAG BMP8500 WALK BESIDE COMPACTOR (A52706)
(INOP) 2018 BOMAG...
2010 Ford Edge SE SUV (A51694)
2010 Ford Edge SE...
2014 INTERNATIONAL DURASTAR 4300 26FT NON CDL BOX TRUCK (A56138)
2014 INTERNATIONAL...
 
Top