MF wet brakes adjustment stud seal.

   / MF wet brakes adjustment stud seal. #1  

RayIN

Platinum Member
Joined
Sep 10, 2024
Messages
722
Tractor
2002 MF 451
Has anyone replaced these seals? Both mine are leaking badly and must be replaced.
I need a "how-to" lesson please.
 
   / MF wet brakes adjustment stud seal. #2  
I assume you are talking about the brake boot? Either drain the oil in the rear end OR jack up or drive the wheel up on a ramp to tilt the tractor to one side so the side lifted up is the side you want to repair.
Remove the adjusting nut on the brake rod and the linkage pin, #48 to get the linkage out of the way. Pry the old seal out of the housing. Put a little RTV sealant on the new boot where it mates with the housing. Tap the new boot around the rim on opposite little by little to get it started. Continue tapping in place until seated. Reassemble linkage and adjuster back. Adjust brakes so that you have about 3/4-1" pedal freeplay.
 

Attachments

  • Brake boot.jpg
    Brake boot.jpg
    223.6 KB · Views: 33
   / MF wet brakes adjustment stud seal.
  • Thread Starter
#3  
I assume you are talking about the brake boot? Either drain the oil in the rear end OR jack up or drive the wheel up on a ramp to tilt the tractor to one side so the side lifted up is the side you want to repair.
Remove the adjusting nut on the brake rod and the linkage pin, #48 to get the linkage out of the way. Pry the old seal out of the housing. Put a little RTV sealant on the new boot where it mates with the housing. Tap the new boot around the rim on opposite little by little to get it started. Continue tapping in place until seated. Reassemble linkage and adjuster back. Adjust brakes so that you have about 3/4-1" pedal freeplay.
I apologize for not responding, for some reason I didn't receive a notification you replied.
Thank you very much! I haven't ordered the seals/boots yet, I've been too busy trying to move everything out of my old pole barn so the contractor can begin the rebuilding.
Every time I park my tractor, those seals leak about 6oz each of hyd oil onto my concrete floor.
I'll get those boots ordered tomorrow.
 
   / MF wet brakes adjustment stud seal. #4  
You also need to push seal over rod lip on inside or it will just keep seeping
 

Tractor & Equipment Auctions

2014 Volkswagen Passat Sedan (A42744)
2014 Volkswagen...
2020 Polaris Ranger 570 Utility Cart (A44572)
2020 Polaris...
2014 Hustler Raptor Zero Turn Mower (A47484)
2014 Hustler...
Kivel 48in Pallet Fork Attachment (A47809)
Kivel 48in Pallet...
2003 Chevrolet S10 Pickup Truck (A44572)
2003 Chevrolet S10...
TPM 18K Mini Excavator (A47809)
TPM 18K Mini...
 
Top