Are block heaters needed?

[MikePA]

I do not have a block heater and I do not need one,but what other options would one have if it was -30 and the tractor sat in an unheated enviroment ? Would the glow plugs be enough to do the job ??

The glow plugs would be enough, assuming your battery has enough juice to run them long enough. I have a block heater and I plug it in the night before snow is called for. I also have a battery charger with a Start engine setting.

 

[ridgerunnerinwv]

The glow plugs would be enough, assuming your battery has enough juice to run them long enough. I have a block heater and I plug it in the night before snow is called for. I also have a battery charger with a Start engine setting.

I never heard of a battery charger like that. I will have to check into that...interesting....

 

[Doc_Bob]

I also have a battery charger with a Start engine setting.

Who makes such a thing?
Bob

 

[herringchoker]

I knew a wise gentleman (who has since passed away) who was a licensed mechanic and manager of a large fleet of cars, trucks and construction equipment. He always said that a cold winter start could take 5,000 miles off the life of an engine due to poor lubrication. I don't know if that is true, especially with today's improved motor oils. However, some sort of engine pre-heat can't hurt. Some of my engines need it to start, others don't, but all are equipped with block heaters or in-line heaters and they are plugged in prior to winter starts. I think it is good insurance.

 

[ovrszd]

I knew a wise gentleman (who has since passed away) who was a licensed mechanic and manager of a large fleet of cars, trucks and construction equipment. He always said that a cold winter start could take 5,000 miles off the life of an engine due to poor lubrication. I don't know if that is true, especially with today's improved motor oils. However, some sort of engine pre-heat can't hurt. Some of my engines need it to start, others don't, but all are equipped with block heaters or in-line heaters and they are plugged in prior to winter starts. I think it is good insurance.

I don't know about the 5,000 mile thing either, but I know it's hard on a diesel when it's doing the blue smoke, missing, shaking, vibrating thing trying to get itself smoothed out. If you don't think it is, stare at the oil gauge the next time you start your diesel in sub freezing temps without a heater and count the seconds from the time you turn the key, until the gauge reads pressure. It's not pretty. If you value your engine and frequently start in sub freezing temps, use a block heater. That's pure common sense.

 

[MikePA]

Who makes such a thing?
Bob

Shumacher is one brand with a model that has a Start Engine setting. Link

 

[Thomas]

Morning Mike.
Neet little unit compare to my old Sears charger w/40amp max starter...thanks for the info...125 must really spin the engine,or does it have safety device built in...only uses the amps it needs to start.

 

[Egon]

I can remember a time when there was no electricity.

Various means were used if the vehicle was not stored in a heatable area.

Hot ashes under the oil pan
Blowtorch on the oil pan
Drain the oil and take inside so it's warm when you put it back in
Take battery into the house
Team of horses to pull vehicle as batteries were not as good then as now and once run down could not be recharged

Or, as many did, use the chores team and sleigh for the chores and for going to town. This also worked much better when the roads were drifted in and not cleared.

Some of the horse drawn vehicles even had enclosed body's with stoves and a windshield to keep the occupants warm. Others used foot warmers. Many kept straw in the wagon box to snuggle down into for warmth. When really cold you had to do some walking to warm up.

 

[Chuck_Lind]

Just had an engine block heater installed on my NH TN65. I'll be using the tractor this winter for snow removal; any device that will increase engine life while making it much easier to start is worth it to me.

I've been told the engine will start up just like it was summer...well, close to summer.

 

[fishpick]

Question (really 2) - how much juice does a block heater consume - is it equivalent to, say, a 100W light bulb?
Second question - can you leave it on "too long" - meaning will it get too hot or cause damage if you leave it on all the time?